Champion Power Equipment 40010 Manuel du propriétaire

40010 Rev 40010-20070427 4000 Peak Watts / 3500 Running Watts PORTABLE GENERATOR Owner’s Manual and Operating Instructions

Controls and Features 6 Rev 40010-20070427 Power Panel (1) Keyed Ignition – Turn the key to the “Start” position to start the generator. Turn to

Controls and Features Rev 40010-20070427 7 Parts Included Your Model 40010 Gasoline Powered Generator ships with the following parts: Spark Arre

Assembly 8 Rev 40010-20070427 Assembly Your generator requires some assembly. This unit ships from our factory without oil. It must be properly servi

Assembly Rev 40010-20070427 9 WARNING Failure to properly ground the generator can result in electric shock. A ground terminal connected to the

Operation 10 Rev 40010-20070427 Operation Generator Location Please consult your local authority. In some areas, generators must be registered with t

Operation Rev 40010-20070427 11 temperatures of the engine and generator. 3. Flip the ignition switch to the “Off” position. 4. Turn the fuel va

Operation 12 Rev 40010-20070427 Wattage Reference Chart Use the chart to determine approximate wattage requirements for your equipment. NOTE Start

Maintenance Rev 40010-20070427 13 Maintenance The owner/operator is responsible for all periodic maintenance. WARNING Never operate a damaged or

Maintenance 14 Rev 40010-20070427 Spark Arrester 1. Allow the engine to cool completely before servicing the spark arrester. 2. Remove the two scre

Storage Rev 40010-20070427 15 Storage The generator should be started at least once every 14 days and allowed to run for at least 20 minutes. For

Specifications 16 Rev 40010-20070427 Specifications Engine Specifications Engine 6.5 HP OHV CPE CARB & EPA certified Generator Specifications

Specifications Rev 40010-20070427 17 Parts Diagram

Specifications 18 Rev 40010-20070427 Parts List No. Part # Description Qty 1 ST168FD-1160100 Fuel Meter Assembly 1 2 GB819-85 Screw M5×6 2 3

Specifications Rev 40010-20070427 19 No. Part # Description Qty 56 ST168FD-1151301 Ornamental 2 57 ST02FD-1151002 Muffler Cover 1 58 ST02F

Specifications 20 Wiring Diagram

Troubleshooting 21 Troubleshooting Problem Cause Solution No fuel Add fuel Faulty spark plug Replace spark plug Generator will not start Unit

Warranty 22 Rev 40010-20070427 Warranty CHAMPION POWER EQUIPMENT 1 YEAR LIMITED WARRANTY Effective September 1, 2006. Replaces all undated warrantie

Warranty Rev 40010-20070427 23 A unit provided as an exchange will be subject to the warranty of the original unit. The length of the warranty gov

Warranty 24 Rev 40010-20070427 Champion Power Equipment, Inc (CPE), The California Air Resources Board (CARB) and the United States Environment Prot

Warranty Rev 40010-20070427 25 EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System W

Table of Contents Introduction ... 1 Portable Power Generator... 1 Accessories...

Warranty 26 Rev 40010-20070427 i. Unapproved add-on or modified parts may not be used to modify or repair a CPE engine. Such use voids this ECS Wa

Notes Rev 40010-20070427 27 Notes

1-877-338-0999 10006 Santa Fe Springs Road Santa Fe Springs, CA 90670 USA Made in China © 2007 Champion Power Equipment, Inc.

Introduction Rev 40010-20070427 1 Introduction Congratulations on your purchase of a Champion Power Equipment generator. CPE designs and builds ge

Manual Conventions 2 Rev 40010-20070427 Manual Conventions This manual uses the following symbols to help differentiate between different kinds of in

Safety Rules Rev 40010-20070427 3 Safety Rules WARNING Read this manual thoroughly before operating your generator. Failure to follow instruc

Safety Rules 4 Rev 40010-20070427 DANGER Fuel and fuel vapors are highly flammable and extremely explosive. Fire or explosion can cause severe burns

Controls and Features Rev 40010-20070427 5 Controls and Features Read this owner’s manual before operating your generator. Familiarize yourself wi